Ford Forum
http://www.ford-forum.net/

Leaking boot!!
http://www.ford-forum.net/viewtopic.php?f=20&t=105		 Page 1 of 1
Author:  Greg [ Sun Aug 24, 2008 4:36 pm ]
Post subject:  Leaking boot!!
Hi guys, i am writing on behalf of my dad. He bought a 2006 focus st off a friend, absolutely mint with only 9k on the clock. He loves every bit about the car but it has somehow developed a leak in the boot :shock: We have stripped it out and have found the passenger side is leaking somewhere as the foam bits stuck to the plastic parts are sodden with water. We have taken the rear cluster off and poured water down but cannot see a leak. From the amount of water that was in the boot we can only assume it is coming in fast. I personally think it is coming in through one of the screw holes for the rear cluster (though it does have a little seal on it.

If anyone has experienced this themselves or knows anything that may help could you please reply to this.

Thanks alot Greg
Author:  graemet [ Tue Dec 02, 2008 8:04 pm ]
Post subject:  Re: Leaking boot!!
We have the same issue on our 2001 Focus. It started to smell inside and we have found the carpet in the boot at the LHS on passenger side is very wet. Also at the bootom going up over the wheel arch.
I'm checking the forums now, and see some advise like:
*this could be comming in from the welds arround the tailgate hinges*.
On one person's site there is a pic supposedly sent by Ford showing the hinge welds.
I'm going to try and check this out on our car and I'll post here if I have success. :|
Author:  PAUL [ Tue Jan 27, 2009 5:44 pm ]
Post subject:  Re: Leaking boot!!
having same problem with my 1999 focus, carpet wet around edges also spare wheel well gets full of water. checked all seals all ok :?
Author:  P. Butler [ Wed Feb 18, 2009 10:44 am ]
Post subject:  Re: Leaking boot!!
Have also found my 2001 3 door 1.8L Focus is getting water in the boot/hatch. I noticed this on the RH side as the foam bit stuck to the boot carpet piece was all wet. Also some water had entered the spare wheel well. I removed the RH interior piece of carpet that covers the RH wheel arch. There is a square piece cut out where you can see a vent with a thin fabric cover over it. The water is getting through only when it rains and the car is parked. The little space/well though the square cut out is where the water collects and eventually runs over the small lip and into the spare wheel well. I have had the RH light cluster off/cleaned and applyed silican around the 2 peg holes and where the screw goes in but it still leaks! It is a slow process as ive had the hosepipe on it and it takes ages for water to come through. Does the black rubber strip on the roof edges (2 of)that runs from front to back pull out? Anybody any ideas?
Butty
York
Author:  RedLester [ Thu Mar 05, 2009 2:42 pm ]
Post subject:  Re: Leaking boot!!
Check the vent with the thin cover as this is where my leak came from. You might need remove the cover, then replace it, using a silicone sealing around the edges to make a watertight seal.
Author:  Old Is Gold [ Tue Jun 22, 2010 9:56 am ]
Post subject:  Re: Leaking boot!!
I would start by trying to trace where the water is coming in from inside the vehicle.If possible remove the internal trims and redo the test to see where the entry point is.
The other option is to remove the rear bumper and check for signs of bad seams ,missing body grommets etc.

Good Luck
Page 1 of 1 All times are UTC
Powered by phpBB © 2000, 2002, 2005, 2007 phpBB Group
http://www.phpbb.com/